Limestone and oyster shell for brown layers in their second egg production cycle

Fundação de Amparo à Pesquisa do Estado de São Paulo (FAPESP)

Effects of adding Bauxite and Oyster shell on the properties of metakaolin-based geopolymer cements

This work has investigated the possibility of use bauxite and oyster shell as mineral admixtures,to enhance the properties of metakaolin-based geopolymer cements. Raw materials(metakaolin, bauxite and oyster shell) were characterized in the first time by determination of their chemical and mineralogical compositions, particles size distribution, specific surface area, thermal analysis and then in the second time use to synthesized geopolymers. Different methods of analysis such as Fourier Transform Infrared spectroscopy(FTIR), X-Ray Diffractometry (XRD), and Scanning Electron Microscopy (SEM) were used to assess the variation of setting time, linear shrinkage and 28 days compressive strength of geopolymer pastes. The results of these analysis has showed that bauxite and oyster shells are source of Al2O3 and CaO respectively, and also contain crystalline phases. The geopolymers obtained by mixing metakaolin and bauxite have their setting time between 235 and 420min and their compressive strength between 40 and 57MPa ; for those obtained by mixing metakaolin and oyster shell the setting time is between 330 and 485min and compressive strength between 40 and 58MPa . The addition of a moderate amount (20% by mass) of bauxite or oyster shell led to improve the compressive strength of a metakaolin-based geopolymer of 43% (metakaolin-bauxite-based geopolymers) and 45% (metakaolin-oyster shell-based geopolymers) and decrease the linear shrinkage. More than 20% mineral additive has a deleterious effect on compressive strength and increase the setting time. Keywords: Metakaolin ; Bauxite ; Oyster shell ; synthesis ; Optimization; Geopolymer cements.

Sistemas de alimentação e suplementação de farinha de casca de ostras sobre o desempenho e a qualidade da casca dos ovos de poedeiras comerciais

O objetivo desta pesquisa foi avaliar diferentes sistemas de alimentação e suplementação de farinha de casca de ostras sobre o desempenho e a qualidade da casca dos ovos, determinados constituintes sangüíneos, e sobre a disponibilidade aparente do cálcio e fósforo dietéticos, em 120 galinhas Lohmann LSL, com 70 semanas de idade, distribuídas em 20 unidades experimentais com seis aves cada. O delineamento utilizado foi o inteiramente ao acaso em arranjo fatorial 2 x 2: sistemas de alimentação (ad libitum e jejum das 7 às 18 h) e suplementação de farinha de casca de ostras (0 e 6,5 g/ave/dia), totalizando quatro tratamentos com cinco repetições cada. Os resultados mostraram menor consumo de ração para as galinhas submetidas à restrição alimentar. Produção, peso e massa de ovos, conversão alimentar, porcentagem de casca, espessura de casca, densidade aparente dos ovos e os coeficientes de disponibilidade aparente do cálcio e fósforo não foram afetados pelos tratamentos. Concluiu-se que o fornecimento de ração após às 18 h e a suplementação de casca de ostras não se mostraram vantajosos para o desempenho e a qualidade da casca dos ovos de poedeiras comerciais.

Temporal tracking of mineralization and transcriptional developments of shell formation during the early life history of pearl oyster Pinctada maxima

Molluscan larval ontogeny is a highly conserved process comprising three principal developmental stages. A characteristic unique to each of these stages is shell design, termed prodissoconch I, prodissoconch II and dissoconch. These shells vary in morphology, mineralogy and microstructure. The discrete temporal transitions in shell biomineralization between these larval stages are utilized in this study to investigate transcriptional involvement in several distinct biomineralization events. Scanning electron microscopy and X-ray diffraction analysis of P. maxima larvae and juveniles collected throughout post-embryonic ontogenesis, document the mineralogy and microstructure of each shelled stage as well as establishing a timeline for transitions in biomineralization. P. maxima larval samples most representative of these biomineralization distinctions and transitions were analyzed for differential gene expression on the microarray platform PmaxArray 1.0. A number of transcripts are reported as differentially expressed in correlation to the mineralization events of P. maxima larval ontogeny. Some of those isolated are known shell matrix genes while others are novel; these are discussed in relation to potential shell formation roles. This interdisciplinary investigation has linked the shell developments of P. maxima larval ontogeny with corresponding gene expression profiles, furthering the elucidation of shell biomineralization.

Investigation of molecular mechanisms regulating biomineralization of pearl oyster Pinctada maxima

Biomineralization is a process encompassing all mineral containing tissues produced within an organism. The most dynamic example of this process is the formation of the mollusk shell, comprising a variety of crystal phases and microstructures. The organic component incorporated within the shell is said to dictate this remarkable architecture. Subsequently, for the past decade considerable research have been undertaken to identify and characterize the protein components involved in biomineralization. Despite these efforts the general understanding of the process remains ambiguous. This study employs a novel molecular approach to further the elucidation of the shell biomineralization. A microarray platform has been custom generated (PmaxArray 1.0) from the pearl oyster Pinctada maxima. PmaxArray 1.0 consists of 4992 expressed sequence tags (ESTs) originating from the mantle, an organ involved in shell formation. This microarray has been used as the primary tool for three separate investigations in an effort to associate transcriptional gene expression from P. maxima to the process of shell biomineralization. The first investigation analyzes the spatial expression of ESTs throughout the mantle organ. The mantle was dissected into five discrete regions and each analyzed for gene expression with PmaxArray 1.0. Over 2000 ESTs were differentially expressed among the tissue sections, identifying five major expression regions. Three of these regions have been proposed to have shell formation functions belonging to nacre, prismatic calcite and periostracum. The spatial gene expression map was confirmed by in situ hybridization, localizing a subset of ESTs from each expression region to the same mantle area. Comparative sequence analysis of ESTs expressed in the proposed shell formation regions with the BLAST tool, revealed a number of the transcripts were novel while others showed significant sequence similarities to previously characterized shell formation genes. The second investigation correlates temporal EST expression during P. maxima larval ontogeny with transitions in shell mineralization during the same period. A timeline documenting the morphologicat microstructural and mineralogical shell characteristics of P. maxima throughout larval ontogeny has been established. Three different shell types were noted based on the physical characters and termed, prodissoconch I, prodissoconch 11 and dissoconch. PmaxArray 1.0 analyzed ESTs expression of animals throughout the larval development of P. maxima, noting up-regulation of 359 ESTs in association with the shell transitions from prodissoconch 1 to prodissoconch 11 to dissoconch. Comparative sequence analysis of these ESTs indicates a number of the transcripts are novel as well as showing significant sequence similarities between ESTs and known shell matrix associated genes and proteins. These ESTs are discussed in relation to the shell characters associated with their temporal expression. The third investigation uses PmaxArray 1.0 to analyze gene expression in the mantle tissue of P. maxima specimens exposed to sub-lethal concentrations of a shell-deforming toxin, tributyltin (TBT). The shell specific effects of TBT are used in this investigation to interpret differential expression of ESTs with respect to shell formation functions. A lethal and sublethal TBT concentration range was established for P. maxima, noting a concentration of 50 ng L- 1 TBT as sub-lethal over a 21 day period. Mantle tissue from P. maxima animals treated with 50 ng L- 1 TBT was assessed for differential EST expression with untreated control animals. A total of 102 ESTs were identified as differentially expressed in association with TBT exposure, comparative sequence identities included an up-regulation of immunity and detoxification related genes and down-regulation of several shell matrix genes. A number of transcripts encoding novel peptides were additionally identified. The potential actions of these genes are discussed with reference to TBT toxicity and shell biomineralization. This thesis has used a microarray platform to analyze gene expression in spatial, temporal and toxicity investigations, revealing the involvement of numerous gene transcripts in specific shell formation functions. Investigation of thousands of transcripts simultaneously has provided a holistic interpretation of the organic components regulating shell biomineralization.

The History of Oyster Farming in Australia

Aboriginal Australians consumed oysters before settlement by Europeans as shown by the large number of kitchen middens along Australia's coast. Flat oysters, Ostrea angasi, were consumed in southeastern Australia, whereas both flat and Sydney rock oysters, Saccostrea glomerata, are found in kitchen middens in southern New South Wales (NSW), but only Sydney rock oysters are found in northern NSW and southern Queensland. Oyster fisheries began with the exploitation of dredge beds, for the use of oyster shell for lime production and oyster meat for consumption. These natural oyster beds were nealy all exhausted by the late 1800's, and they have not recovered. Oyster farming, one of the oldest aquaculture industries in Australia, began as the oyster fisheries declined in the late 1800's. Early attempts at farming flat oysters in Tasmania, Victoria, and South Australia, which started in the 1880's, were abandoned in the 1890's. However, a thriving Sydney rock oyster industry developed from primitive beginnings in NSW in the 1870's. Sydney rock oysters are farmed in NSW, southern Queensland, and at Albany, Western Australia (WA). Pacific oysters, Crassostrea gigas, are produced in Tasmania, South Australia, and Port Stephens, NSW. FLant oysters currently are farmed only in NSW, and there is also some small-scale harvesting of tropical species, the coarl rock or milky oyster, S. cucullata, and th black-lip oyster, Striostrea mytiloides, in northern Queensland. Despite intra- and interstate rivalries, oyster farmers are gradually realizing that they are all part of one industry, and this is reflected by the establishment of the national Australian Shellfish Quality Assuarance Program and the transfer of farming technology between states. Australia's oyster harvests have remained relatively stable since Sydney rock oyster production peaked in the mid 1970's at 13 million dozen. By the end of the 1990's this had stabilized at around 8 million dozen, and Pacific oyster production reached a total of 6.5 million dozen from Tasmania, South Australia, and Port Stephens, a total of 14.5 million dozen oysters for the whole country. This small increase in production during a time of substantial human population growth shows a smaller per capita consumption and a declining use of oysters as a "side-dish."

Development of low-cost feed for culture of giant freshwater prawn (Macrobrachium rosenbergii de Man) in ponds

An experiment was conducted for 105 days in 12 earthen mini ponds of each 30m² size. Five different experimental diets containing 32% protein were formulated and prepared using fishmeal, shrimp meal, soybean meal, mustard oil cake, sesame meal, wheat bran and rice bran. A commercial shrimp diet (SABINCO starter-III) was assigned to treatment six and considered as the control. Prawns were stocked at the rate of 2.5 fry/m² and feed twice daily at the rate of 10% at the beginning and reduced to 8% for the last two months. The results of the experiment showed that prawn fed diets 1, 2, and 6 (control) showed significantly (P<0.05) highest weight gain among the dietary groups, while prawn fed diet 5 showed significantly lowest weight gain. The FCR values of diets ranged between 3.06 to 4.85. Prawns fed diet 1 and 6 showed significantly higher SGR, survival (%) and production among the dietary groups. The survival (%) of the prawns ranged between 46.6 to 66.6% and the production ranged between 304.5 to 563.3 kg/ha/105 days. The result of the study showed that diet containing 30% fishmeal, 5% shrimp meal, 5% soybean meal, 10% mustard oil cake, 10% sesame meal, 20% wheat bran, 18% rice bran, 1% oyster shell and 1% vitamin premix may be recommended for monoculture of M. rosenbergii.

Effect of farm made feeds on polyculture of shrimp (Penaeus monodon) and three brackishwater finfish species

A study was conducted to evaluate the effects of feed made from locally available ingredients on polyculture of shrimp and three brackishwater finfish species. Hatchery produced post-larvae (PL) of shrimp Penaeus monodon (0.005g) were stocked at the rate of 15,000 PLs/ha. Brackishwater finfish species Liza parsia, Mugil cephalus and Rhinomugil corsula of 0.63-1.4lg collected from local rivers were stocked at the rate 8,000, 1,000 and 2,000/ha, respectively in four treatments. Shrimp and finfishes were fed four different experimental diets composed of fish meal, mustard oil cake, rice bran, oyster shell power and vitamin premixes at the rate of 3-5% estimated crop/day for 195 days. Among four treatments, P. monodon showed comparative better growth in T4 and T3. Finfish L. parsia showed its better performance in treatment T2. Species M. cephalus and R. corsula showed insignificant production. P. monodon showed better growth with diet of fish meal and mustard oil cake@ 28.84 and 33.65%, respectively in T 3 and 19.22 and 43.27%, respectively in treatment T4.

Effects of different types of feeds on growth and production of tiger shrimp, Penaeus monodon at Bagerhat region, Bangladesh

An experiment was carried out in farmers' gher (shrimp farm) at Bagerhat sadar upazilla, Bagerhat to ascertain the effects of three different types of feeds on the production and economics of brackishwater shrimp, Penaeus monodon for a period of 120 days. There were three treatments such as T1 (BFRI dough feed containing of 30% fish meal, 10% protein conc., 10% soya meal, 15% mustard oil cake, 18% rice bran, 5% maize, 10% wheat flour, 1% oyster shell powder and 1% vitamin premix), T2 (Commercial diet Saudi-Bangla grower) and T3 (Saudi-Bangla special feed). Each treatment had two replicates and the stocking of shrimp in each gher was 3 nos/m². Water quality parameters did not differ significantly among the treatments except water depth. Average production and net return of shrimp in different treatments varied from 404.0 to 509.0 kg/ha and Tk. 56,493.99-Tk. 84,209.60, respectively. T2 showed significantly (p<0.05) the highest production and economic return. The result of the study implied that T2 is more suitable and economically viable than that of other treatments for shrimp farming.

A von Bertalanffy Based Model for the Estimation of Oyster (Crassostrea virginica) Growth on Restored Oyster Reefs in Chesapeake Bay

A model to estimate the mean monthly growth of Crassostrea virginica oysters in Chesapeake Bay was developed. This model is based on the classic von Bertalanffy growth function, however the growth constant is changed every monthly timestep in response to short term changes in temperature and salinity. Using a dynamically varying growth constant allows the model to capture seasonal oscillations in growth, and growth responses to changing environmental conditions that previous applications of the von Bertalanffy model do not capture. This model is further expanded to include an estimation of Perkinsus marinus impacts on growth rates as well as estimations of ecosystem services provided by a restored oyster bar over time. The model was validated by comparing growth estimates from the model to oyster shell height observations from a variety of restoration sites in the upper Chesapeake Bay. Without using the P. marinus impact on growth, the model consistently overestimates mean oyster growth. However, when P. marinus effects are included in the model, the model estimates match the observed mean shell height closely for at least the first 3 years of growth. The estimates of ecosystem services suggested by this model imply that even with high levels of mortality on an oyster reef, the ecosystem services provided by that reef can still be maintained by growth for several years. Because larger oyster filter more water than smaller ones, larger oysters contribute more to the filtration and nutrient removal ecosystem services of the reef. Therefore a reef with an abundance of larger oysters will provide better filtration and nutrient removal. This implies that if an oyster restoration project is trying to improve water quality through oyster filtration, it is important to maintain the larger older oysters on the reef.

Marine or estuarine radiocarbon reservoir corrections for mollusks? A case study from a medieval site in the south of England

Mollusk shells are frequently radiocarbon dated and provide reliable calibrated age ranges when the regional marine reservoir correction is well-established. For mollusks from an estuarine environment the reservoir correction may be significantly different than the regional marine reservoir correction due to the input of bedrock or soil derived carbonates. Some mollusk species such as oysters are tolerant of a significant range of salinities which makes it difficult to determine which reservoir correction is appropriate. A case study is presented of an anomalous radiocarbon age for an oyster shell paint dish found in the fabric of the ruined nave walls of St Mary's Church, Shoreham-by-Sea, West Sussex, England. Stable isotopes (delta O-18 and delta C-13) were used to establish the type of environment in which the oyster had lived. Paired marine and terrestrial samples from a nearby medieval site were radiocarbon dated to provide an appropriate reservoir correction.

Sistemas de Alimentação com Livre Escolha e Semi Livre Escolha para Poedeiras

This research was carried out to verify the ability of laying hens to select food in order to meet their requirements for protein and energy. Ninety-six Hy-Line White laying hens, 45 weeks old, were allotted to a randomized block design with two blocks (two ranges of body weight), four treatments, and three replicates of four hens in each block. The treatments consisted of four different feeding systems: I-Conventional feeding represented by a complete ration composed of 60% ground corn and 40% protein concentrate; 2-Free-choice feeding with ground corn, protein concentrate and oyster shells fed in feeders with three separate compartments; 3-Semi free-choice feeding with whole corn grain, protein concentrate and oyster shells in the same proportion in one feeder; 4-Free-choice feeding with whole corn grain, protein concentrate and oyster shells fed in feeders with three separate compartments. The results indicated that the hens, in spite of age, adapt to different feeding systems, and that they can select feed to meet their nutrient requirements. The semi free-choice and free-choice feeding systems with whole corn grain resulted in the same performance compared to conventional feeding, but shell quality was not improved by oyster shell supplementation. However, the worst performance was with free-choice feeding with ground corn, which indicated that in the free-choice feeding system the use of whole corn grain is recommended.

Bioremediation of phosphates in seawater: approach for recirculating marine aquaculture effluents

Marine Recirculating Aquaculture Systems (RAS) produce great volume of wastewater, which may be reutilized/recirculated or reutilized after undergoing different treatment/remediation methods, or partly discharged into neighbour water-bodies (DWW). Phosphates, in particular, are usually accumulated at high concentrations in DWW, both because its monitoring is not compulsory for fish production since it is not a limiting parameter, and also because there is no specific treatment so far developed to remove them, especially in what concerns saltwater effluents. As such, this work addresses two main scientific questions. One of them regards the understanding of the actual (bio)remediation methods applied to effluents produced in marine RAS, by identifying their advantages, drawbacks and gaps concerning their exploitation in saltwater effluents. The second one is the development of a new, innovative and efficient method for the treatment of saltwater effluents that potentially fulfil the gaps identified in the conventional treatments. Thereby, the aims of this thesis are: (i) to revise the conventional treatments targeting major contaminants in marine RAS effluents, with a particular focus on the bioremediation approaches already conducted for phosphates; (ii) to characterize and evaluate the potential of oyster-shell waste collected in Ria de Aveiro as a bioremediation agent of phosphates spiked into artificial saltwater, over different influencing factors (e.g., oyster-shell pre-treatment through calcination, particle size, adsorbent concentration). Despite the use of oyster-shells for phosphorous (P) removal has already been applied in freshwater, its biosorptive potential for P in saltwater was never evaluated, as far as I am aware. The results herein generated showed that NOS is mainly composed by carbonates, which are almost completely converted into lime (CaO) after calcination (COS). Such pre-treatment allowed obtaining a more reactive material for P removal, since higher removal percentages and adsorption capacity was observed for COS. Smaller particle size fractions for both NOS and COS samples also increased P removal. Kinetic models showed that NOS adsorption followed, simultaneously, Elovich and Intraparticle Difusion kinetic models, suggesting that P removal is both a diffusional and chemically rate-controlled process. The percentage of P removal by COS was not controlled by Intraparticle Diffusion and the Elovich model was the kinetic model that best fitted phosphate removal. This work demonstrated that waste oyster-shells, either NOS or COS, could be used as an effective biosorbent for P removal from seawater. Thereby, this biomaterial can sustain a cost-effective and eco-friendly bioremediation strategy with potential application in marine RAS.